廚房設備/廚房的設置，是餐飲產品“部件 ”的生產場所，是模塊化生產的要求和體現。
The setting of central kitchen equipment / central kitchen is the production place of "components" of catering products and the requirement and embodiment of modular production.
在具體的實踐中，相對于傳統的廚房設計，它還有如下幾大優點：
In specific practice, compared with the traditional kitchen design, it also has the following advantages:
1、有利于統一半成品加工規格，實現模塊化生產所依賴的標準化，保證菜肴出品質量；
1. It is conducive to unify the processing specifications of semi-finished products, realize the standardization that modular production depends on, and ensure the quality of dishes;
2、統一原料的申領與購買，有利于集中審核控制；
2. Unified application and purchase of raw materials is conducive to centralized audit control;
3、便于原料綜合利用和進行細致的成本控制工作；
3. Facilitate the comprehensive utilization of raw materials and detailed cost control;
4、有利于提高廚房的勞動效率；
4. It is conducive to improve the labor efficiency of the kitchen;
5、有利于廚房的垃圾清運和衛生管理等其他工作；
5. It is conducive to other work such as garbage removal and sanitation management in the kitchen;
6、有利于進行大批量生產，降低材料成本和人工成本。這也是廚房運作與大批量定制觀念相一致的重要體現。
6. It is conducive to mass production and reduce material and labor costs. This is also an important embodiment of the central mass customization concept.
廚房規劃設施要求：
Central kitchen planning facility requirements:
1、廚房內照明應在750勒克斯以上，而屬于檢查檢驗作業區，應要保持在1500勒克斯以上，燈具以下在作業上為佳，否則應加護罩，避免燈管破裂。斷電照明應配合消防法規而設置。
1. The lighting in the central kitchen should be more than 750 lux, but in the inspection and inspection operation area, it should be more than 1500 lux. It is better to operate below the lamps, otherwise it should be covered to avoid the rupture of the lamp tube. Power off lighting shall be set in accordance with fire regulations.
2、廚房地板應以、耐熱、堅硬不透水、非吸收性質地板為佳，以及耐磨不光滑的地磚，并需有適當?shù)呐潘倍取?/div>
2. The central kitchen floor should be non-toxic, heat-resistant, hard, impervious and non absorbent, as well as wear-resistant and unsmooth floor tiles, and should have appropriate drainage slope.
3、廚房的排水溝應具有防鼠或其他生物入侵的設施，溝板以不生銹、不光滑者為佳。水溝底部要有適當?shù)幕《燃皟A斜度，不可讓廢水逆流，溝內不可有各式的配管，如水、電、瓦斯管等。
3. The drainage ditch of the central kitchen shall be equipped with facilities to prevent the invasion of rats or other organisms. The ditch plate that is not rusty and smooth is preferred. Proper radian and inclination shall be provided at the bottom of the ditch, and the reverse flow of waste water is not allowed. All kinds of piping, such as water, electricity and gas pipes, are not allowed in the ditch.
4、廚房屋頂應以平坦、無裂縫且易于清掃為佳，以防止灰塵堆積。如有A形屋頂架構者，應加裝天花板并保持密閉，材料應選擇白色，防水、、光滑等，以降低昆蟲生長幾率。
4. The central kitchen roof should be flat, crack free and easy to clean to prevent dust accumulation. If there is A-shaped roof structure, the ceiling shall be installed and kept closed. The material shall be white, waterproof, non-toxic and smooth, so as to reduce the growth rate of insects.
5、廚房的墻壁應平坦無裂縫，且應由地面以上120厘米處，以非吸收性，耐酸、易清洗之建材構筑。壁面與地面宜有圓角弧少3厘米以上，以利清洗及作業。
5. The wall of the central kitchen should be flat without cracks, and should be constructed of non absorbent, acid resistant and easy to clean building materials 120 cm above the ground. The wall surface and the ground should have a fillet arc of at least 3cm to facilitate cleaning and disinfection.
6、廚房的門窗及換氣口等凡是能開放的地方，應設置有防鼠、昆蟲等入侵的設施，門片也要能自動關閉，并要設置空氣簾或防蠅簾，主要推車行走的動線門片，應設防止碰撞護墊，紗窗或換氣口應設易拆洗不生銹紗窗，且網目大小應合適。
6. The doors, windows and air vents of the central kitchen shall be equipped with anti rat, insect and other invasion facilities where they can be opened. The door panel shall also be able to close automatically, and air curtain or fly curtain shall be set. The moving door panel of the main cart shall be equipped with anti-collision pad. The screen window or air vent shall be equipped with easy to remove and wash non rust screen window, and the mesh size shall be appropriate.
7、廚房應有充分的供水及儲水設備，及符合水質標準規定，如清洗水或飲用水的區分，應以明顯顏色區分。地下水及凈水設備，應與污染源保持距離，儲水塔應加鎖并常清洗，并使用非透明這貯水塔。
7. The central kitchen shall have sufficient water supply and storage equipment and meet the requirements of water quality standards. For example, the distinction between cleaning water and drinking water shall be distinguished by obvious colors. The underground water and water purification equipment shall be kept away from the pollution source. The water storage tower shall be locked and cleaned frequently, and the non-toxic and non transparent water storage tower shall be used.
8、廚房內一切配管線應按標準的施工法則來施工，而電源插座必須防水，不同的電壓，應有明顯的標志及漏電斷電的系統。
8. All piping lines in the central kitchen should be constructed according to the standard construction rules, and the power socket must be waterproof. Different voltages should have obvious signs and leakage power-off system.
9、廚房區內要設置廁所，則應男女分開，廁所門方向不可對向作業場所，應每日刷洗保持清潔，龍頭應采用感應式并有清潔劑或系統。廁所應有良好通風設施，及防蠅設備。以上是屬于建筑結構及水電供應配合的部分，當然配合得越完善，要求 得越嚴格，食品的衛生就越有保障。
9. If toilets should be set in the kitchen area, men and women should be separated. The direction of the toilet door should not face the workplace. It should be brushed and cleaned every day. The faucet should be inductive and equipped with detergent or disinfection system. The toilet shall have good ventilation facilities and fly prevention equipment. The above is part of the coordination of building structure and water and electricity supply. Of course, the more perfect and strict the coordination is, the more guaranteed the hygiene of food will be.
10、另外，廚房還要配備一定數量的明火加熱設備。在菜肴原料的加工工作中，有些干貨原料的漲發和鮮活原料的宰殺、褪毛需要進行熱處理，如大烏參發前要火烤，豬腳爪要用火燎等。因此，在廚房的合適位置配備明火加熱設備是十分必需的。當然，有加熱設備就應注意加熱源的和所產生煙氣的脫排問題，這些都在設計者的考慮范圍之內。
10. In addition, the central kitchen should be equipped with a certain number of open fire heating equipment. In the processing of dish raw materials, the rise of some dry raw materials and the slaughter and depilation of fresh raw materials need heat treatment, such as fire roasting before the hair of Dawu ginseng, burning pig feet and claws, etc. Therefore, it is very necessary to equip open fire heating equipment at the appropriate position of the central kitchen. Of course, if there is heating equipment, we should pay attention to the safety of heating source and the discharge of flue gas, which are within the consideration of designers.
新聞 / NEWS RECOMMENDATIONS
